pump

Hi i recentley changed my coolant and after a ride i noticed a little bit of coolant drip from underneath the water pump. its never done it before. only thing i touched on the water pump was the drain screw.. if that seal goes inside the water pump i know it drips from the weep hole but my...

In need of a fuel pump for an 07 FZ6 (all the same?) Mainly need the float because the previous owner removed/broke it so it is missing. Thanks

Picked up a neglected but running 04 FZ6. Worst rust I've ever seen in a gas tank, there must be two pounds of it in there. Fuel was pouring out the front top of the tank at every stop where dozens of bubbles under the paint were bursting and seeping fuel. Ebay yielded a decent tank and you...

Anyone found a fuel level sender replacement without replacing the entire fuel pump denso makes and sells them for cars yamaha wants to sell entire pump assembly

On mobile, bear with me! So, 06 fz6 with about 17k miles or so. So, this spring I started having issues with starting. Bike runs fine once going, and doesnt have an issue restarting. Only happens afyer sitting at least a couple hours. What happens is I have to crank the bike either more than...

Hello, So I know 12.89V isn't ideal but I believe that should be enough to even just power accessories and have the instrument cluster turn on as well as fuel pump. Does anyone know what could cause that? I know this is super vague, but basically I turn the key and it literally does...

Hey guys hope doing fine!! I been a owner of a FZ6 2004 since dicember and when I first got it the bike would rev up to red line. Since a couple of weeks I been having the issue that it wont rev up fast anymore, after it reaches 12k rpms it goes up slow to 14k. Any clues what I can check ...

Hi peeps! Been a while and im trying to bring life back into my FZ6. Have not rode her this year so I was doing all the fluids and a battery change. My memory is failing me and I dont recall what I should expect. Mainly I need to know what the bike should do when you put in the key and push...

Hi Guys New on here 1st post...whooo hoo.... Know this has been asked before but along long time ago.2009. I want to know if anyone has a picture or photograph as to the clip that removes the block on the pump housing. Someone who did this previously said you had to unclip by putting...

This thread has been edited and closed! Thanks.

Hello, I checked battery voltage using diagnostic mod from cluster. (d-09 shows battery voltage) It shows 11.4V while fuel pump motor is active. (.You have to turn on kill switch to see battery voltage, and it automatically switches fuel pump motor) Batter is a 4-5 year old Yuasa. It...

I have a 2004 fz6 was riding it pretty hard about a week ago and it suddenly died. Got to looking at it and the fuel pump wouldnt kick on. So i cut the wires to the fuel pump connector to test the pump by hooking 12v to it and it works. So i thought that maybe the starter cutoff relay was bad...

Hey guys. I've used seafoam as a fuel additive in the past and it's worked great for me. I know there are a few other uses such as adding it in the oil a few miles (~100) before the next oil change and adding it directly into the fuel pump. I was wondering if anyone else can chime in on...

Hey everyone, I've been through these threads for a while now. I know everything is mostly old, but it is still super helpful. Recently my FZ6 was stolen and the meth head busted it all up. Ripped the mirrors and all lights off (yes, ripped off, a screw driver or wrench was not used)...

I'm replacing the fuel pump on '08 Fz6. Hoping some one can help me out with a picture of the underside of their tank. Trying to remember which hoses go where. I apologize if this has already been covered previously.

The fuel pump in my '06 FZ6 died. Yamaha Canada wants ~$700 for a new one. My mechanic suggested checking eBay for a previously enjoyed unit. Found one for about $150 shipped. The new-to-me used fuel pump is installed and working, but my mechanic says there is some hesitation / lag when you...

Hi, Last year, I bought a wrecked 2007 FZ6 for a go-cart. The guy started and it ran the engine. Been in garage for about a year so I figured I should change fuel and run it for awhile. I drained the fuel and put in about a 1/2 gallon. When I turn it on, the pump did not prime. so I went...

Wondering what Octane everyone is running. User manual states that 87 is fine, what do you guys do?

Hi Guys and Girls :welcome: I will try to make this short as possible. My bike has had minor starting issues from the time I bought it two years ago. The fuel pump always primed but sometimes I would have to open the throttle to get it started, and occasionally it would start from cold and just...

Hey all, I have a 2005 FZ6N and I broke the fuel outlet for the fuel pump assembly. I was wondering if anyone had one sitting around or was wrecking an fz. I am located in brisbane but could go for postage if required. cheers,