pump

I've seen other posts on this and I haven't figured out my issue. Got the bike all cleaned up, new battery ( it was throwing out a code ) cleared the codes, cleaned out the gas tank. Removed and changed fuel pump rotor. Cleaned out pressure relief valve also and it seemed to hold pressure up...

Ok.. so I had painted my Fz6 last spring. The reason I haven't posted photos is the clear coat didn't come out well and I am not happy with the result I plan on respraying the tank first in the fall and then the plastics over the winter This time I very much do not want to have to empty the...

I had the bike apart for a repaint and the fuel pump was removed, wrapped and stored over the winter Now since putting the bike back together no matter how little gas is in the tank the gauge always reads full. I checked the connectors and I removed the pump to see if the arm was stuck. I...

Hi all, I'm new to the forum and new to the FZ6. I just bought one used from 2004 some days ago and I am getting accustomed to it. Question to you: When I am driving I can here some kind of constant whistle like a Larsen effect. I went to a Yamaha dealer and they listened to the motorbike...

This started happening a few months ago - when I start my FZ6 and rev the engine within the first minute or so it hesitates to rev up. The idle is smooth but in neutral or under power it is almost like it is low on fuel. My mileage has been consistent at 42mpg, I started using yamahas...

I took my fuel pump out of my tank this past week to drain the fuel and repaint the tank. Where does that little black wire go??? The fuel pump is off of a 2006 fz6 fazer...

2005 Fz6 - somebody change "guage" to "gauge" in my subject >.> So my bike sat for two years. Yeah. I had a family member that was supposed to start it and run it for a few minutes every week while I was out of the country, but they "couldn't figure out how to turn the key" and didn't call to...

While adding a USB charging port I accidentally bumped my tank and knocked it off the bike. This pulled the wires/terminals out of the plug and broke the fuel line. Not too big of a deal. I installed a new fuel line and wire the pump back up. When I turn the key I can hear the pump whirring and...

Good evening everyone I'm really desperate. I ask your help. I have a yamaha fz6 n 2004 and I disassembled the fuel pump. When I removed the pump motor are also removed two pieces: 1 oring 1 piece of plastic Now I can not more to replace the fuel pump. These two pieces are to be...

So I took out my fuel pump, troubleshooting a crappy running bike. I wanted to check the screen for debris. So I get it apart, clean screen material with compressed air, re-assemble. I get it all back together and now the bike won't run when giving any throttle. It does start and idle...

When I have my autotune connected to my power commander v, the fuel pump continues to prime. It starts throwing code 43 and 46. I've tried different combinations and it always does this as soon as I connect the autotune. It's really odd because it never did that beforehand. Is it possible my...

Anyone have a bad fuel pump that still has its connectors in good shape? I snapped the fuel outlet after owning my FZ6 less than a week. Since it doesn't seem like I can buy just the outlet, TownsendsFJR1300 recommended looking for a broken pump to rebuild mine...

I bought a used 2004 FZ6 on Monday and am still working out the gremlins. A few minutes ago I went to investigate why the fuel gauge sensor wasn't working. Turns out it wasn't plugged in, and plugging it in fixed it. Alright, quick victories! But in the process of putting everything up, I...

Hi everyone. There is a whistle noise/sound from water pump. Sound is very very annoying at idle, 1200 rpm and if bike is cold or warm, no whistle. The whistle sound is only when bike is full warm. Also, sound goes when bike revved 1600 or up, no water mixing marks on motor oil or there is not...

I have a '05 FZ6 and it was crashed a few years back but runs fine, until lately lol. I decided to go street fighter with it, havent changed any wireing or anything, just put a different exaust on it flipped the handle bars romoved all the fairings, it was running fine, even with the new pipe on...

Does anyone have an oil pump cover for an 86-88 FZ6s?

This is a mod I made and it includes using rain-x. Tired of using a bag of water and squeezing it on my visor, to clean the dirty water from the cars in front, without rubbing and scratching the shield,...... I put a water pump and now I spray water any time I want... And mantain my visor...

Hi everyone, I noticed that my radiator fluid was a bit low last weekend so I topped it up, by raising the tank to get to the filler cap. I didn't do any other modifications to the bike. I ran the bike for about 2 mins after that while moving it back to the garage, then switched it off and...